Home - Return to Previous Page
Additional Images

'05-'07 GDP Fuel Boss Mechanical Lift Pump System

FB-05007
Was: $669.00
Sale: $649.00
Save: 3%
Save: $20.00

Customize Your Item

- Drive Options -
 * required
Qty:

Description

Fuel Boss Mechanical Lift Pump System

The latest offering in the GDP pump line is the FUEL BOSS mechanical lift pump system! The FUEL BOSS is a belt driven mechanical lift pump that increase output and pressure to match engine RPM.

Common electronic failures of the factory in-tank lift pump are eliminated. The stock in-tank lift pump will now only run for a few seconds at each start. After startup the stock unit is turned off via a Hobbs pressure switch and will not run again until the next start up cycle. The stock lift pump is not required for proper Fuel Boss operation and is used only for priming the fuel canister after a filter change!

The FB-1000 pump supplied in the FUEL BOSS kit has no bearings to wear out and is a straight cut gear pump capable of pressures well above 100 psi. Running at a 2-1 reduction the FB-1000 turns only half of the engines RPM which is a mere 25% of its rated RPM at cruise. With proper belt tension the FB-1000 will easily last the life of your truck!

Extreme pump longevity is only one of the numerous benefits provided by the FUEL BOSS system. All FUEL BOSS pumps also come equipped with a 100% Viton lip seal which makes them perfect for ULSD, Bio Diesel use and Veg Oil conversions.

FUEL BOSS drive systems are comprised of high strength polycarbonate drive pulleys and nylon covered, fiberglass reinforced, neoprene belts. Belt changes are recommended at 50k to 75k intervals.

Tied to the engine’s RPM via the crank mounted drive pulley the FUEL BOSS will increase output and pressure any time you increase engine RPM. This is truly an engine driven high output system! Minimum fuel pressures at idle and maximum flow at engine redline, just the way it should have been from the factory. Tap the throttle and watch your fuel pressure gauge rise instead of fall!

The FUEL BOSS can fuel any truck from stock to the wildest, twin CP-3 fed power plant imaginable! For extreme trucks we offer a Hyper-Drive belt and pulley combo which will increase pump speed and output an additional 20% over the stock 2 to 1 drive combo provided.

**Note** Only for trucks with stock harmonic balancers. Due to dimensional differences this system will not work with aftermarket harmonic balancers such as the Fluidampr® brand balancers.

Details

Shipping Information

  • Item Requires Shipping
  • 15.0 lbs.
  • W12.0000” x H12.0000” x L6.0000”

Customer Reviews

Comment Total Reviews (6)

Best Thing I Have Done
  • Currently 5/5 Stars

Reviewed by: Anonymous09/20/2017 10:49AM

Product ownership: Less than 1 year

Purchased from: Glacier Diesel Power, Inc.

Comments:
Reviewer: sidney n. From UT US

Had a Noisey Raptor 150 that would suck down on mountains. I went with the fuel boss without the electrical back up 1 year ago. My truck starts faster and fuel pressure climbs the more I give it the gas. When I change filters it is not a problem she fires up just fine. I am Straight Mechanical.

Review
  • Currently 5/5 Stars

Reviewed by: Anonymous09/20/2017 10:49AM

Product ownership: Less than 1 year

Purchased from: Glacier Diesel Power, Inc.

Comments:
Reviewer: Chris R From TX US

I bought this kit after I installed a fuel pressure gauge and notices I was dropping to 5psi when I put the hammer down. I looked at all the electric fuel pumps but at the end of the day I do not want something that I cant pull off and work on myself. If the belt breaks I have an extra in my tool box. At Idle I see anywhere from 10-15 psi, and cruising at 2.2K RPMs I am around 20-23 psi. Not a difficult install dropping the tank is without a doubt the hardest part, unless you are using a pump. Flow back line can be put in by removing the rear fender wheel panel. I did have some questions just to verify that I was doing everything right and Richard answered and called back on a SUNDAY!! BEST CUSTOMER SERVICE IN THE NATION. I will not buy anything for my truck from anyone else.

great pump and company
  • Currently 5/5 Stars

Reviewed by: Anonymous09/20/2017 10:50AM

Product ownership: Less than 1 year

Purchased from: Glacier Diesel Power, Inc.

Comments:
Reviewer: Terry N. From AZ US

I bought this pump because I saw a lot of people raving about there customer service. When I first installed I did have a issue it was taken care of immediately. I recently had another that was of my own fault. But Richard was very helpful with suggestions to find the problem. Extremely happy with my purchase. Everything people say about glaciers great customer service is true. I will definately buy from them in the future.

Great Product!!!
  • Currently 5/5 Stars

Reviewed by: Anonymous09/20/2017 10:51AM

Product ownership: Less than 1 year

Purchased from: Glacier Diesel Power, Inc.

Comments:
Reviewer: Joseph A. From WA USA

Excellent instruction and beautiful machine work! This kit is a work of art. Even with the tight tolerances on my 05 Ram it bolted up like it was meant to be there! On top of that the customer service from Richard is second to none in the diesel world.

Thanks to Richard and crew!

Get one!
  • Currently 5/5 Stars

Reviewed by: Anonymous09/20/2017 10:51AM

Product ownership: Less than 1 year

Purchased from: Glacier Diesel Power, Inc.

Comments:
Reviewer: Frank R. From USA

I put one on my 2nd gen but I wanted everyone to know how much I like this pump. I never should have waited to try one of these. I don't think twice about taking my RV cross country anymore. Goodbye lift pump worries! Thanx Richard!

*Stupid Cool*
  • Currently 5/5 Stars

Reviewed by: Anonymous09/20/2017 10:52AM

Product ownership: Less than 1 year

Purchased from: Glacier Diesel Power, Inc.

Comments:
Reviewer: Jeff B. From USA

This is just the coolest thing I've done to my truck yet. Switched over from FASS and I'm sooooo glad I did! No more noise and no more watching the fuel pressure drop when I'm on it HARD! Everything fit perfect and the install wasn't bad at all. My brother didn't believe me until he rode in the truck. Now he's going to order one too! Thanx guys...

You must login to post a review.